[Date Prev][Date Next][Thread Prev][Thread Next][Date Index][Thread Index]
need part #
Alright you had to get me in the garage at 8 am on a friday morning eh! well
here is what I have discovered.
these are 1 engine 1.8 JH from 84 and 85 scirocco
First this one orientates the plate location
<http://longcoeur.com/scirocco/various/P8080186.JPG>
Second is the plate removed (yes there is a hole behind it!)
<http://longcoeur.com/scirocco/various/P8080187.JPG>
BUT!
I discovered after removing the plate that the JH in 85 did not have a
gasket like the other JH in 84 (plate is also different - vw does it again)
The 84 plate was flat in the back with a gasket... but my 85, well it has an
O-RING incased in the plate check it out!
<http://longcoeur.com/scirocco/various/P8080189.JPG>
Any other questions I can answer visually for you ???
ATS - Patrick Bureau - txrocco@sbcglobal.net
----------------------------------------------
MSN:ATSGTX@hotmail.com |YAHOO:ATSGTX@yahoo.com
ICQ:32918816 |AIM:Texasscirocco
----------------------------------------------
=>-----Original Message-----
=>From: scirocco-l-bounces@scirocco.org
=>[mailto:scirocco-l-bounces@scirocco.org]On Behalf Of Dan Bubb
=>Sent: Friday, August 08, 2003 8:55 AM
=>To: Drew MacPherson; ATS - Patrick Bureau
=>Cc: _Scirocco Mailing List
=>Subject: Re: need part #
=>
=>
=>Not only the diesel, but I believe 1.6 and 1.7 gas engines had a
=>hole in the
=>block where the fuel pump was mounted if the car had a
=>carburetor. When they
=>went to CIS they just put a blockoff plate over the hole.
=>ETKA tends to reuse graphics if they even remotely show the situation, so
=>the accuracy of the sketch can't be counted on too much.
=>Dan
=>
=>----- Original Message -----
=>From: "Drew MacPherson" <drew@scirocco.cs.uoguelph.ca>
=>To: "ATS - Patrick Bureau" <txrocco@sbcglobal.net>
=>Cc: "_Scirocco Mailing List" <scirocco-l@scirocco.org>
=>Sent: Friday, August 08, 2003 9:34 AM
=>Subject: RE: need part #
=>
=>
=>>
=>> Not meaning to offend Patrick, but that picture is actually a 1.6L
=>> Diesel/TD block - note the oil squirters?
=>>
=>> The blockoff plate seen at (9) is the diesel blockoff plate.
=>>
=>> Reference JEG 86:1:03:3-00 - you'll note that it's the same picture, but
=>> the 1.8 block is the bottom one, the 1.6D/TD is the top one.
=>>
=>> There's no indication of a gasket on the 1.8, although there is
=>a hole in
=>> the picture.
=>>
=>> Drew
=>>
=>>
=>> On Fri, 8 Aug 2003, ATS - Patrick Bureau wrote:
=>>
=>> > Hey old 16v dudes... listen up (oh I do love mornings like theses)
=>> >
=>> > Actually on the JH engine, the warm up regulator unit sit on a plate
=>that
=>> > itself sits on a gasket that is bolted with 2 hex screws.
=>> > See picture on and look at item #9
=>> > <http://longcoeur.com/scirocco/various/blockjh.jpg>
=>> >
=>> > now the problem is that there is no part number anymore.
=>> >
=>> > Dan if you need one, and your old one is too mangled to make a copy
=>(from
=>> > single sheet gasket that you can buy at AutoZone) I have one unused, I
=>can
=>> > trace it out for ya on a square of the proper material, and
=>mail to you
=>if
=>> > you like. or scan it for you to print and cut up.. either way LMK.
=>> >
=>> > ATS - Patrick Bureau - txrocco@sbcglobal.net
=>> > ----------------------------------------------
=>> > MSN:ATSGTX@hotmail.com |YAHOO:ATSGTX@yahoo.com
=>> > ICQ:32918816 |AIM:Texasscirocco
=>> > ----------------------------------------------
=>> >
=>> >
=>> > =>-----Original Message-----
=>> > =>From: scirocco-l-bounces@scirocco.org
=>> > =>[mailto:scirocco-l-bounces@scirocco.org]On Behalf Of Dan Bubb
=>> > =>Sent: Friday, August 08, 2003 7:21 AM
=>> > =>To: Dan Smith; scirocco-l@scirocco.org
=>> > =>Subject: Re: need part #
=>> > =>
=>> > =>
=>> > =>I could be wrong, but I don't believe there is a gasket under the
=>warmup
=>> > =>regulator/control pressure regulator. I don't think the JH has a
=>> > =>hole in the
=>> > =>block in this location. Or at least ETKA doesn't show it or any
=>gasket.
=>> > =>The ABA and PL have breather holes in the block, but not the JH.
=>> > =>Shoot me if I'm wrong.
=>> > =>Dan
=>> > =>
=>> > =>----- Original Message -----
=>> > =>From: "Dan Smith" <sad_rocc@yahoo.com>
=>> > =>To: <scirocco-l@scirocco.org>
=>> > =>Sent: Friday, August 08, 2003 2:32 AM
=>> > =>Subject: need part #
=>> > =>
=>> > =>
=>> > =>> I need the part number for a gasket (ETKA part number that is).
=>> > =>Ok, let me
=>> > =>try to describe it.... Above and to the left of the oil
=>filter/sender
=>unit
=>> > =>is the fuel control pressure regulator or something like that. It
=>> > =>has 2 fuel
=>> > =>lines going into it and connects to the block. I need the
=>seal that is
=>> > =>inbetween that and the block, I believe it's where the block-off
=>> > =>plate would
=>> > =>go. This is for an 84 mk2 8v, JH engine. Hopefully you know what
=>> > =>I'm talking
=>> > =>about as I need to call a stealership tommorrow to make
=>sure they have
=>it.
=>> > =>Also, is it pronounced E.T.K.A. or ET (like let without the 'L') KA?
=>> > =>>
=>> > =>> TIA,
=>> > =>> Dan
=>> > =>>
=>> > =>>
=>> > =>> ---------------------------------
=>> > =>> Do you Yahoo!?
=>> > =>> The New Yahoo! Search - Faster. Easier. Bingo.
=>> > =>> _______________________________________________
=>> > =>> Scirocco-l mailing list
=>> > =>> Scirocco-l@scirocco.org
=>> > =>> http://neubayern.net/mailman/listinfo/scirocco-l
=>> > =>
=>> > =>
=>> > =>
=>> > =>_______________________________________________
=>> > =>Scirocco-l mailing list
=>> > =>Scirocco-l@scirocco.org
=>> > =>http://neubayern.net/mailman/listinfo/scirocco-l
=>> >
=>> >
=>> > _______________________________________________
=>> > Scirocco-l mailing list
=>> > Scirocco-l@scirocco.org
=>> > http://neubayern.net/mailman/listinfo/scirocco-l
=>> >
=>>
=>> --
=>> /=============================================\
=>> | 84 Wolfsburg Edition TurboDiesel Scirocco |
=>> | http://scirocco.cs.uoguelph.ca/gtd |
=>> \=============================================/
=>>
=>>
=>> _______________________________________________
=>> Scirocco-l mailing list
=>> Scirocco-l@scirocco.org
=>> http://neubayern.net/mailman/listinfo/scirocco-l
=>
=>
=>
=>_______________________________________________
=>Scirocco-l mailing list
=>Scirocco-l@scirocco.org
=>http://neubayern.net/mailman/listinfo/scirocco-l