[Date Prev][Date Next][Thread Prev][Thread Next][Date Index][Thread Index]
2.0 swap in NorCal
The price of LSD alone is scary enough for me... Love to have one... but can
think of a lot of other ways to spend...
David L. Winchell, II
DavidWinchell2@sprynet.com
87 16V Scirocco
86 8V Scirocco
01 V6 Galant
00 Silverado
www.cardomain.com/id/xavsbud
-----Original Message-----
From: scirocco-l-bounces@scirocco.org
[mailto:scirocco-l-bounces@scirocco.org]On Behalf Of Euroroc II
Sent: Monday, August 18, 2003 2:04 AM
To: Scirocco-l@scirocco.org
Subject: RE: 2.0 swap in NorCal
Prices scare me... They range a lot to too much :-)
-Raffi
Oh Sh*t I forgot to get duct tape! Can I get this at the dealer or is there
some aftermarket stuff that's better?
At 08:19 PM 8/17/2003 -0400, you wrote:
>Raffi, quite an extensive list! I noticed that there were no prices
>next to any of the items, was that intentional? I never want to see the
>grand total either.
>
>Good luck with the project, I can't wait to see the pictures!
>
>BTW, what transmission are you using? I noticed you listed a 2.0
>pressure plate, is that the one for a GLI or a GTI?
>
>Rick K.
>
>-----Original Message-----
>From: scirocco-l-bounces@scirocco.org
>[mailto:scirocco-l-bounces@scirocco.org] On Behalf Of Euroroc II
>Sent: Saturday, August 16, 2003 5:15 PM
>To: Jeff Toomasson; Scirocco-l@scirocco.org
>Subject: RE: 2.0 swap in NorCal
>
>You asked for it...
>
>Started with;
>Volkswagon 9A 2.0L 16V Engine
>Block hot tanked, new bearings,
>rings, seals. Head has new Hydraulic
>Lifters (Followers) and Oil Seals.
>Run 3K miles before car was totaled...
>
>
>Parts I've replaced from memory & I'm too afraid to look at the growing
>stack of receipts
>
>Water Pump & Housing New
>Water Pump O-Ring New
>AC compressor Sanden SD-508 New
>Alternator New 120 Amp Audi
>Alternator Adjuster Bracket (toothed ) Cleaned
>Alternator adjuster Bracket (toothed) New
>AC Bracket Reconditioned Black
>Breather Reconditioned Cast Aluminum
>Breather Seal New
>Breather O-Ring New
>Oil Flange Reconditioned Cast Aluminum
>Oil Flange Seal New
>Water Flange (Front) Reconditioned Cast Aluminum
>Water Flange (Side) Reconditioned Cast Aluminum
>Water Flange Seal (Front) New
>Water Flange Seal (Side) New
>Intake Manifold (Upper & Lower ) Brushed Finish Brushed runners
>and
>blue lettering
>Intake Manifold Seal New Manifold to head
>Intake Manifold Seal New Upper to Lower
>Throttle Body Seal New Throttle body to intake
>Throttle Body Seal New Throttle body to boot
>Cold Start Flange Reconditioned Lite Polish (No
>Bling-Bling)
>Cold Start Flange Seal New To Lower Intake
>Cold Start Valve Seal New
>Water pump pulley bolts New
>Water Pump special screws New Double ended
>Power Steering Pulley Bolts New
>Crank Pulley Bolts (Harmonic Balancer) New
>Water Pump screws New upper bolts
>Intake Manifold Bracket Reconditioned Low gloss black (
>2
>parts)
>Injector seats (brass) Reconditioned Polished
>Injector seats (Air Shroud) New
>Injector seat O-Rings New
>Exhaust Manifold Reconditioned Sand blasted and
>1600F ceramic paint
>Exhaust Manifold Seals New Manifold to head (4x)
>Exhaust Manifold Seal New Manifold to downpipe
>Exhaust manifold Studs New M8 (8X)
>Exhaust Manifold Nuts New M8 Copper Plated (8x)
>Exhaust Manifold Studs New M10 (6x)
>Exhaust Manifold Nuts New M10 (6x)
>Timing Belt New
>Timing Belt Tensioner New
>Timing Belt Tensioner Stud New
>Timing Belt Tensioner Washer New
>Timing Belt Tensioner Nut New
>Techtonics Cam Set New
>Timing Chain New
>Valve Cover Reconditioned Cast Aluminum and
>polished fins
>Oil Pan New
>Oil Pump New
>Windage Tray New
>Valve Cover gasket New Rubber
>Starter Replace From Spare parts
>Engine Mount (TT version) New Near Timing belt, all others
>
>are < 6 months old
>2.0L Pressure Plate New Clutch disk < 5 months old
>Pressure Plate Bolts New
>Flywheel Bolts New Lightened flywheel < 5
>months old
>V-Belt New
>Alternator Belt New
>Distributor Plug Reconditioned Black
>Distributor Plug Seal New O-Ring
>Distributor Plug Seal New Paper
>TT Cams New
>Nuts & Bolts New Replaced almost all of them
>:-P
>Nuts & Bolts Cleaned the ones I didn't
>replace... I think there are 5 of them :-)
>
>80% LSD kit for 020 Tranny New
>
>Have all the Motronic stuff but that goes in after the motor is running
>with the current CIS-E system. I'll take pictures.
>
>-Raffi
>
>
>At 10:34 AM 8/16/2003 -0700, Jeff Toomasson wrote:
> >Are you SURE you want to see the list? Do you have a YEAR?! :)
> >
> >Seriously, this swap is as close to "New In Box" as I can imagine.
> >
> >Jason was just here picking up the engine hoist. Looks like I'll be
> >getting dirty next Saturday! :)
> >
> >Hope everyone's enjoying their weekend! L8R, JT
> >
> >Rick Kellner <rfkellner@snet.net> wrote:
> >Raffi,
> >Any chance you could post some of the vital statistics on the
> >project? You mentioned a list of new parts; that would be interesting
> >to see. Also the information on the 'fiddly bits'. A list of the big
> >items is always something to share such as 2.0l head? Ported?
> >Motronic?
> >Pictures are always great to share too.
> >Good luck with the project!
> >
> >Rick Kellner.
> >
> >-----Original Message-----
> >From: scirocco-l-bounces@scirocco.org
> >[mailto:scirocco-l-bounces@scirocco.org] On Behalf Of Euroroc II
> >Sent: Saturday, August 16, 2003 4:54 AM
> >To: Scirocco-l@scirocco.org
> >Subject: 2.0 swap in NorCal
> >
> >Well almost all the parts have been purchased (very long list). Who
>need
> >a
> >savings account???
> >Manifolds are done.
> >Cams are in.
> >All the fiddley bits have been replaced or reconditioned.
> >Motor is getting transported tomorrow morning from where I was working
> >on
> >it to the place it will be installed. Big thanks to Jason Kambic for
> >donating his garage so I can have a place to work! This is very
>generous
> >
> >since I'm basically booting his MK1 out to do it!
> >
> >Swap starts next weekend! WooHoo!
> >
> >Just had to share...
> >-Raffi
> >
> >
> >_______________________________________________
> >Scirocco-l mailing list
> >Scirocco-l@scirocco.org
> >http://neubayern.net/mailman/listinfo/scirocco-l
> >
> >
> >_______________________________________________
> >Scirocco-l mailing list
> >Scirocco-l@scirocco.org
> >http://neubayern.net/mailman/listinfo/scirocco-l
> >
> >
> >---------------------------------
> >Do you Yahoo!?
> >Yahoo! SiteBuilder - Free, easy-to-use web site design software
> >_______________________________________________
> >Scirocco-l mailing list
> >Scirocco-l@scirocco.org
> >http://neubayern.net/mailman/listinfo/scirocco-l
>
>
>_______________________________________________
>Scirocco-l mailing list
>Scirocco-l@scirocco.org
>http://neubayern.net/mailman/listinfo/scirocco-l
>
>
>_______________________________________________
>Scirocco-l mailing list
>Scirocco-l@scirocco.org
>http://neubayern.net/mailman/listinfo/scirocco-l
_______________________________________________
Scirocco-l mailing list
Scirocco-l@scirocco.org
http://neubayern.net/mailman/listinfo/scirocco-l